ENGINE

All internally lubricated engine parts including: pistons, piston rings, piston pins, crankshaft, main bearings, connecting rods, connecting rod bearings, camshaft, camshaft bearings, timing chain or belt (timing belt must be serviced according to manufacturer’s recommendations to qualify for coverage), timing gears, tensioners / guides, intake and exhaust valves, valve train, valve springs, valve guides, push rods, rocker arms, rocker arm shafts, lifters, oil pump and oil pump housing; intake & exhaust manifold; distributor shaft and housing; harmonic balancer; valve covers; timing gear cover; water pump; mounts; air filter housing; thermostatically controlled air intake; oil pan; engine block and heads are covered if damaged by the mechanical breakdown of an internally lubricated moving part.

TRANSMISSION

All internal parts; mounts; transmission pan and case are covered if damaged by the mechanical breakdown of an internally lubricated moving part.

AUTOMATIC: torque converter, front pump, planetary gear set, clutches; clutch apply piston, internal sealing rings, input and output shafts, roller clutches, bands, check balls, band apply servo, drums, centre support, governor assembly, vacuum modulator, valve body, stator and stator shaft, bushings, pressure regulator valve and bearings. CVT (Continuously Variable Transmission): transaxle assembly; valve body, CVT belt, and pulleys. DCT (Dual Clutch Transmission): Dual-clutch assembly.

MANUAL: Gears, shafts, bearings, bushings, counter shaft, synchronizers, synchronizer sleeves, detent balls, thrust washers, shift forks, levers, collars, and springs. Note: No Coverage is afforded for clutch assembly; slave cylinder; pressure plate; flywheel; throw-out bearing; worn synchronizers or cables.

HYBRID/ELECTRIC VEHICLE

Hybrid Control Unit(s) including inverter; stator and rotor; battery sensors; cooling fan; cooling duct(s); high voltage harness and junction box; electric drive motor(s); drive battery pack.

TURBO/ SUPERCHARGER

All internal parts; housing is covered if damaged by the mechanical breakdown of an internally lubricated moving part.

TRANSFER UNIT

All internal parts; case is covered if damaged by the mechanical breakdown of an internally lubricated moving part.

DRIVE AXLE(S)

All internal parts; “U” joints; propeller shafts; CV / Tripod joints; drive shafts, drive shaft yokes, drive shaft carrier, axle shafts, front hubs, locking hubs, differential case is covered if damaged by the MECHANICAL BREAKDOWN of an internally lubricated moving part.

STEERING

All internal parts in rack and pinion; steering box; power steering pump; power steering cooler.

SUSPENSION

Upper and lower control arms, control arm shafts and bushings; upper and lower ball joints; stabilizer shaft, coil and leaf springs; spindles and spindle supports.

ELECTRICAL

Alternator; voltage regulator; starter motor, drive and solenoid; starter relay; front and rear wiper motor including circuit board, switches for power windows, electronic ignition module, distributor, washer pump relay and delay switch; cruise control servo, module and transducer; heater blower motor; power antenna motor; power door lock actuators; trunk actuator; electronic digital instrument cluster.

ELECTRONICS

Electronic Spark Control (ESC) module, Electronic Engine Control (EEC) module; Engine Control Module (ECM); Powertrain Control Module (PCM); Transmission Control Module (TCM); oxygen sensor(s); Idle Air Control (IAC) valve; Manifold Air Pressure (MAP) sensor; Mass Air Flow (MAF) sensor; Throttle Position Sensor (TPS); Crankshaft Position Sensor (CKP); calibration prom; EFI sensors.

BRAKES

Master cylinder; wheel cylinders; calipers; combination valve; Anti-Lock Brakes (ABS) electronic control unit; wheel speed sensors / exciters; hydraulic pump / motor assembly; accumulator; pressure modulator valve; isolation dump valve, power assist booster and valve; steel lines and fittings; clips and retainers.

AIR CONDITIONING

Compressor; condenser; receiver dryer; accumulator, clutch; expansion valve; orifice tube; evaporator.

COOLING

Radiator fan; engine, cooling fan motors; water pump, radiator; temperature sensors.

FUEL DELIVERY

Fuel pump; vacuum pump; injection pump; metal fuel lines; throttle body assembly.

SEALS AND GASKETS

Seals and gaskets are covered for the above listed assemblies only in conjunction with a covered repair.

Coverage so comprehensive that if it’s not on the short list of exclusions*, it is covered. Ultimate XO coverage includes all components covered under XO-1and XO-2 coverage PLUS hundreds more, such as;

• Wheel Hub Assembly
• Vehicle Fluid Coolers
• Heated Seat Elements
• Rain Sensing Wiper System
• Driver Assist Sensors
• Seat Memory Modules
• Seat Recliner
• Fuel Rail
• Air Door Motors
• Anti-Theft Devices
• Steering Assist Module

*See service contract or mechanical breakdown insurance policy terms and conditions for full details of coverage and exclusions.

ENHANCED SEALS AND GASKETS (Included in Ultimate XO):

Seals and gaskets for all covered assemblies are covered independently or in conjunction with a covered repair.

HYDRAULIC SUSPENSION (OEM ONLY):

Coverage is provided for all of the Manufacturer installed mechanical, electrical and hydraulic components of the hydraulic suspension system, except for those items listed under “Exclusions”.

AIR BLADDER SUSPENSION (OEM ONLY):

Coverage is provided for all of the Manufacturer installed mechanical, electrical and pneumatic components of the air suspension system, except for those items listed under “Exclusions”.